TM-9-2350-287-20-1 Carrier Ammunition Tracked M992A21 (2350-01-352-3021) EIC:AE6 Manual

CHAPTER 1 INTRODUCTION - TM-9-2350-287-20-1_21
1-5. QUALITY ASSURANCE
1-9. SAFETY, CARE, AND HANDLING
Section II. EQUIPMENT DESCRIPTION AND DATA - TM-9-2350-287-20-1_24
1-12. LOCATION AND DESCRIPTION OF MAJOR COMPONENTS
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS (continued). - TM-9-2350-287-20-1_26
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS (continued). - TM-9-2350-287-20-1_27
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS (continued). - TM-9-2350-287-20-1_28
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS (continued).
LOCATION AND DESCRIPTION OF MAJOR COMPONENTS (continued) - TM-9-2350-287-20-1_30
1-13. DIFFERENCES BETWEEN MODELS
DIFFERENCES BETWEEN MODELS (continued)
1-14. EQUIPMENT DATA. - TM-9-2350-287-20-1_33
TRANSMISSION - TM-9-2350-287-20-1_34
AUTOMATIC FIRE EXTINGUISHING SYSTEM (AFES) - TM-9-2350-287-20-1_35
AUXILIARY POWER UNIT - TM-9-2350-287-20-1_36
Section III. PRINCIPLES OF OPERATION - TM-9-2350-287-20-1_37
TRANSMISSION AND DRIVE CONTROL ASSEMBLIES - TM-9-2350-287-20-1_38
1-16. EQUIPMENT OPERATION (continued).
ENGINE COOLING SYSTEM - TM-9-2350-287-20-1_40
FUEL SYSTEM - TM-9-2350-287-20-1_41
APU
HYDRAULIC SYSTEM OPERATION - TM-9-2350-287-20-1_43
CONVEYOR SYSTEM - TM-9-2350-287-20-1_45
CONVEYOR SYSTEM - TM-9-2350-287-20-1_46
UPPER REAR DOOR - TM-9-2350-287-20-1_47
SUSPENSION SYSTEM - TM-9-2350-287-20-1_48
NBC VENTILATED FACE PIECE SYSTEM - TM-9-2350-287-20-1_49
DRIVERS INSTRUMENT PANELS
DRIVERS INSTRUMENT PANELS (continued)
CHAPTER 2 GENERAL MAINTENANCE PROCEDURES
2-1. GENERAL
2-5. GENERAL INSPECTION AND REPAIR PROCEDURES
a. ENGINE AFES CHECK
c. 1. 2. 3. Remove locking pin from crew compartment extinguishers No. 3 and No. 4 valve actuator guards connected by mechanical cable to actuator assembly (para 21 -3). Make sure the other four extinguishers locking pins are installed. Remove antirecoil plug from six crew compartment extinguishers (para 21-3). Place nozzles on extinguishers (para 21-3). Turn Maintenance switch on crew T/A panel to horizontal position (para 21 -3). Make sure green POWER ON lamp lights and green PASS TEST lamp lights and then goes out, indicating that system is operational. Momentarily hold SYSTEM TEST/LAMP TEST toggle switch on crew T/A panel to LAMP/TEST. Verify that all four Iamp and all LEDs light. Time permitting, perform crew AFES system test (refer to TM 9-2350-287- 10). AFES MANUAL DISCHARGE SYSTEM CHECK
2-7. SERVICING AND CONNECTING BATTERIES
b. CONNECTING
SERVICING AND CONNECTING BATTERIES (continued) - TM-9-2350-287-20-1_60
SERVICING AND CONNECTING BATTERIES (continued).
SERVICING AND CONNECTING BATTERIES (continued) - TM-9-2350-287-20-1_62
2-8. RADIATOR FAN PROTECTIVE SCREEN REPLACEMENT
2-9. INTERCONNECTIONS.
2-13. SERVICE INTERVALS
2-15. GENERAL PMCS PROCEDURES (continued)
2-16. SPECIFIC PMCS PROCEDURES (continued)
TABLE 2-1. PREVENTIVE MAINTENANCE CHECKS AND SERVICES
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_69
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_70
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_71
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_72
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_73
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_74
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_75
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_76
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_77
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_78
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_79
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_80
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_81
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_82
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_83
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_84
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_85
2-17. ELECTRICAL TROUBLESHOOTING
2-18. QUICK GUIDE TO TROUBLESHOOTING
QUICK GUIDE TO TROUBLESHOOTING (continued) - TM-9-2350-287-20-1_88
QUICK GUIDE TO TROUBLESHOOTING (continued) - TM-9-2350-287-20-1_89
QUICK GUIDE TO TROUBLESHOOTING (continued) - TM-9-2350-287-20-1_90
QUICK GUIDE TO TROUBLESHOOTING (continued) - TM-9-2350-287-20-1_91
QUICK GUIDE TO TROUBLESHOOTING (continued) - TM-9-2350-287-20-1_92
QUICK GUIDE TO TROUBLESHOOTING (continued).
2-19.   TROUBLESHOOTING   CHART
(1) ENGINE CRANKS SLOWLY, BATTERY INDICATOR LOW YELLOW OR RED
(2) ENGINE DOES NOT ACCELERATE PROPERLY, DOES NOT DEVELOP FULL POWER
(3) ENGINE HAS LOW OR NO OIL PRESSURE
(4) ENGINE OVERHEATS
(5) ENGINE CRANKS, BUT WILL NOT START
b. ENGINE - FUEL SYSTEM.
(2) ENGINE DOES NOT ACCELERATE PROPERLY, DOES DEVELOP FULL POWER, or does not maintain steady RPM
c. ENGINE - COOLANT SYSTEM
(1) ENGINE OVERHEATS (continued).
d. ENGINE, ELECTRICAL SYSTEM.
(1) ENGINE DOES NOT CRANK. All other electrical systems operate (continued)
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_106
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_107
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_108
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_109
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_110
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_111
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_112
(2) ENGINE CRANKS SLOWLY, BATTERY lNDlCA- TOR IN LOW YELLOW OR RED.
(3) ENGINE CRANKS, BUT WILL NOT START.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_115
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_116
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_117
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_118
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_119
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_120
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_121
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_122
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_123
(4) ONE OR MORE GLOW PLUGS FAIL TO OPERATE
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_125
(5) ENGINE CRANKS, BUT WILL NOT START IN COLD WEATHER OR GLOW PLUG SYSTEM FAILS TO OPERATE.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_127
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_128
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_129
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_130
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_131
e. AIR CLEANER FAN ASSEMBLY
(1) AIR CLEANER BLOWER MOTORS DO NOT OPERATE WITH VEHICLE IN GEAR
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_134
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_135
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_136
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_137
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_138
f. GENERATOR
(1) GENERATOR FAILS TO CHARGE BATTERIES. GAGE INDICATES NOT CHARGING, UNSTEADY, OR INACCURATE READING
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_141
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_142
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_143
g.   GAGES.
BATTERY / GENERATOR GAGE CIRCUIT
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_146
TRANSMISSION OIL TEMPERATURE GAGE CIRCUIT
ENGINE OIL PRESSURE GAGE CIRCUIT
ENGINE WATER TEMPERATURE GAGE CIRCUIT
FUEL GAGE CIRCUIT
(1) ENGINE OIL PRESSURE GAGE FAILS TO OPERATE WITH ENGINE RUNNING.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_152
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_153
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_154
(2) ENGINE COOLANT TEMPERATURE GAGE FAILS TO OPERATE PROPERLY, NEEDLE DOES NOT MOVE, IS STEADY, OR INACCURATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_156
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_157
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_158
(3) TRANSMISSION OIL PRESSURE GAGE FAILS TO OPERATE.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_160
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_161
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_162
(4) TRANSMISSION OIL TEMPERATURE GAGE FAILS TO INDICATE OIL TEMPERATURE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_164
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_165
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_166
(5) FUEL GAGE FAILS TO INDICATE A LEVEL READ- ING WITH BOTH FUEL TANKS FULL
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_168
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_169
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_170
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_171
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_172
(6) FUEL GAGE FAILS TO INDICATE LEVEL OF UPPER FUEL TANK.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_174
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_175
(7) FUEL GAGE FAILS TO INDICATE LEVEL OF LOWER FUEL TANK
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_177
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_178
(8) BATTERY/GENERATOR GAGE FAILS TO OPER- ATE PROPERLY - NO OR UNSTEADY READING
(9) TACHOMETER FAILS TO OPERATE WHEN ENGINE IS RUNNING
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_181
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_182
(10) SPEEDOMETER FAILS TO OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_184
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_185
h.   LIGHTS
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_187
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_188
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_189
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_190
(I) PORTABLE INSTRUMENT PANEL MASTER WARNING LIGHT FAILS TO OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_192
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_193
(2) STEERING SHAFT MASTER WARNING LIGHT FAILS TO OPERATE. Other MASTER WARN- ING light operates
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_195
(3) MASTER WARNING LIGHT FAILS TO OPERATE WHEN ENGINE OVERHEATS.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_197
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_198
(4) ENGINE LOW LEVEL COOLANT LIGHT FAILS TO OPERATE WHEN PRESSED-TO-TEST.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_200
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_201
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_202
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_203
(5) GLOW PLUG WAIT LIGHT FAILS TO OPERATE, ENGINE STARTS IN COLD WEATHER (BELOW 50 F).
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_205
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_206
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_207
(6) MASTER SWITCH INDICATOR LIGHT FAILS TO OPERATE WITH MASTER SWITCH ON
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_209
(7) HIGH BEAM INDICATOR LIGHT FAILS TO OPERATE.
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_211
(8) PARKING BRAKE INDICATOR LIGHT FAILS TO OPERATE.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_213
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_214
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_215
(9) PERSONNEL HEATER INDICATOR LED FAILS TO OPERATE WHEN PRESSED-TO-TEST OR WITH HEATER OPERATING
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_217
(10) ONE OR BOTH HEADLIGHTS FAIL TO OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_219
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_220
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_221
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_222
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_223
(11 ) ONE OR BOTH BLACKOUT (BO) DRIVE LIGHTS FAIL TO OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_225
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_226
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_227
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_228
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_229
(12) FRONT BLACKOUT (BO) MARKER LEDS FAIL TO OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_231
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_232
(13) TAILLIGHTS FAIL TO OPERATE.
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_234
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_235
(14) STOPLIGHT FAILS TO OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_237
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_238
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_239
(15) ONE OR BOTH REAR BUCKOUT (BO) MARKER LEDs FAIL TO OPERATE.
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_241
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_242
(16) BLACKOUT (BO) STOP LED FAILS TO OPERATE.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_244
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_245
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_246
(17) PORTABLE INSTRUMENT PANEL LIGHTS FAIL TO OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_248
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_249
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_250
(18) ACCESSORY CONTROL BOX PANEL LIGHTS FAIL TO OPERATE
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_252
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_253
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_254
(19) DOME LIGHT FAILS TO OPERATE
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_256
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_257
i. NATO SLAVE RECEPTACLES.
(1) NO POWER TO VEHICLE FROM NATO SLAVE RECEPTACLE.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_260
(2) NO POWER AT INTERNAL OR EXTERNAL POWER RECEPTACLE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_262
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_263
i AUXILIARY OUTLET
(1) AUXILIARY OUTLET FAILS TO OPERATE.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_266
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_267
k. TRANSMISSION AND DRIVING CONTROLS.
(1) TRANSMISSION OVERHEATS, TRANSMISSION (continued). OIL TEMPERATURE GAGE READS OVER 285F (140C). MASTER WARNING LIGHT IS LIT
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_270
(2) VEHICLE DOES NOT MOVE. TRANSMISSION (continued). DOES NOT OPERATE IN ANY SHlFT POSITION.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_272
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_273
(3) VEHICLE DOES NOT STEER IN EITHER DIRECTION IN ANY RANGE.
1. TRACK AND SUSPENSION.
(1) VEHICLE BRAKES POORLY
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_277
(2) VEHICLE PULLS TO ONE SIDE WITH STEERING WHEEL IN CENTER POSITION
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_279
(3) VEHICLE THROWS TRACK.
m. BILGE PUMP.
(1) BILGE PUMP DOES NOT OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_283
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_284
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_285
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_286
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_287
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_288
n. PERSONNEL HEATER
(1) PERSONNEL HEATER FAILS TO OPERATE.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_291
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_292
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_293
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_294
(2) HEATER MOTOR RUNS BUT FAILS TO OPERATE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_296
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_297
(3) PERSONNEL HEATER CONTINUES RUNNING WITH HEAT SELECTOR SWITCH TURNED OFF
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_299
o. PERSONNEL VENTILATION BLOWER
(1) PERSONNEL VENTILATION BLOWER DOES NOT OPERATE.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_302
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_303
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_304
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_305
(2) PERSONNEL VENTILATION BLOWER DOES NOT OPERATE IN INTAKE MODE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_307
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_308
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_309
(3) PERSONNEL VENTILATION BLOWER DOES NOT OPERATE IN EXHAUST MODE
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_311
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_312
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_313
4) PERSONNEL VENTILATION BLOWER OPER- ATES, BUT DOES NOT COME ON AUTOMATI- CALLY IN EXHAUST MODE DURING AFES TEST
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_315
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_316
p. CONVEYOR
(1)   CONVEYOR CHAIN WILL NOT OPERATE IN EITHER DIRECTION.
(1)   CONVEYOR CHAIN WILL NOT OPERATE IN EITHER DIRECTION.
q. PRIMARY ROTARY PUMP.
(1) INSUFFICIENT OR NO HYDRAULIC PRESSURE
s. UPPER REAR DOOR.
(1)   UPPER REAR DOOR DOES NOT GO UP OR DOWN.
s. UPPER REAR DOOR.
(1) UPPER REAR DOOR DOES NOT GO UP OR DOWN.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_327
(2) UPPER REAR DOOR DRIFTS CLOSED
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_329
(3) ACTUATOR OPERATION IS SLOW OR ERRATIC.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_331
t. HYDRAULIC ELECTRICAL SYSTEMS
(1) UPPER REAR DOOR DOES NOT GO UP OR DOWN
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_334
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_335
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_336
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_337
(2) CONVEYOR CHAIN WILL NOT OPERATE IN EITHER DIRECTION
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_339
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_340
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_341
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_342
u. AUXILIARY POWER UNIT (APU).
(1) ENGINE CRANKS BUT FAILS TO START
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_345
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_346
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_347
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_348
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_349
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_350
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_351
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_352
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_353
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_354
(2) ENGINE FAILS TO CRANK.
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_356
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_357
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_358
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_359
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_360
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_361
(3) ENGINE HARD TO START
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_363
(4) ENGINE STARTS, BUT FAILS TO KEEP RUNNING OR MISFIRES
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_365
(5) ENGINE OVERHEATS
TROUBLESHOOTING   CHART   (continued). - TM-9-2350-287-20-1_367
TROUBLESHOOTING   CHART   (continued). - TM-9-2350-287-20-1_368
(6)   GENERATOR CHARGING SYSTEM INDICATOR READS IN LOW YELLOW OR RED WITH MAIN ENGINE CHARGING.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_370
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_371
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_372
v. AFES, ENGINE
(1) POWER ON LAMP DOES NOT LIGHT WHEN MASTER SWITCH IS ON
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_375
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_376
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_377
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_378
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_379
(2)   FIRE WIRE (F/W) LED REMAINS ON, NO FIRE PRESENT
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_381
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_382
(3) FAULT LAMP REMAINS ON. AUTO LED IS LIT
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_384
FAULT LAMP REMAINS ON. MANUAL LED IS LIT
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_386
(5) BOTH ENGINE BOTTLES DISCHARGE WHEN MANUAL SWITCH ON ENGINE AFES T/A PANEL IS ACTIVATED
(6) BOTTLES NOT DISCHARGING WHEN PULLING MANUAL CABLES
FIGURE 2 ENGINE COMPARTMENT TEST SETUP
(7) AFES MEGOMETER TROUBLESHOOTING PROCEDURES
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_391
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_392
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_393
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_394
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_395
w. AFES, CREW.
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_397
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_398
(1) POWER ON LAMP DOES NOT LIGHT WHEN MASTER SWITCH IS TURNED ON.
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_400
TROUBLESHOOTING   CHART   (continued) - TM-9-2350-287-20-1_401
(2) FAULT LAMP REMAINS LIT. FIRE DET. LED'S LIT
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_403
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_404
(3) FIRE EXT. LEDS ARE LIT. FAULT LAMP REMAINS ON.
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_406
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_407
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_408
(4) CREW BOTTLES DISCHARGING WITHOUT BEING ACTIVATED
(5) CREW BOTTLES NOT FULLY DISCHARGING/ NOT EXTINGUISHING FIRES.
(6) BOTTLES NOT DISCHARGING WHEN PULLING MANUAL CABLES.
CREW COMPARTMENT TEST SETUP - TM-9-2350-287-20-1_412
(7) AFES MEGOMETER TROUBLESHOOTING PROCEDURES.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_414
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_415
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_416
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_417
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_418
x. NBC SYSTEM
(1) NO FAN OPERATION FROM M2A2 AIR PURIFIER.
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_421
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_422
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_423
TROUBLESHOOTING CHART (continued) - TM-9-2350-287-20-1_424
(2) ONE OR MORE M3 UNITS (ELECTRIC AIR HEATERS) FAIL TO OPERATE.
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_426
TROUBLESHOOTING CHART (continued). - TM-9-2350-287-20-1_427
b. PMCS Test Method.
c. STE/lCE Troubleshooting Method.
GENERAL STE/lCE TEST METHODS (continued).
2-21. QUICK GUIDE TO STE/lCE TROUBLESHOOTING
QUICK GUIDE TO STE/lCE TROUBLESHOOTING. -CONT
2-22. SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE)
a. STE/lCE PMCS - (continued).
(1) VTM CONNECTIONS AND CHECKOUT FOR DCA (continued).
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/lCE) (continued) - TM-9-2350-287-20-1_436
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/lCE) (continued) - TM-9-2350-287-20-1_437
(2) VTM CONNECTIONS AND CHECKOUT FOR TK
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/lCE) (continued) - TM-9-2350-287-20-1_439
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/lCE) (continued) - TM-9-2350-287-20-1_440
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/lCE) (continued) - TM-9-2350-287-20-1_441
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/lCE) (continued) - TM-9-2350-287-20-1_442
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/lCE) (continued) - TM-9-2350-287-20-1_443
(3) CURRENT FIRST PEAK TEST - DCA.
(4) CURRENT FIRST PEAK TEST - TK.
(5) ENGINE START AND LUBRICATION CHECK - DC/L
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE) (continued) - TM-9-2350-287-20-1_447
(6) ENGINE START AND LUBRICATION CHECK - TK.
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/lCE) (continued) - TM-9-2350-287-20-1_449
(7) CHARGING VOLTAGE TEST - DCA.
(8) CHARGING VOLTAGE TEST - TK.
(9) COOLANT CHECK/ENGINE OIL PRESSURE GAGE TEST - DCA.
(10) COOLANT CHECK/ENGINE OIL PRESSURE GAGE TEST - TK.
(11 ) GOVERNOR CHECK/POWER TEST - DCA
(12) GOVERNOR CHECK/POWER TEST - TK.
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE) (continued). - TM-9-2350-287-20-1_456
(13) IDLE SPEED CHECK - DCA.
(14) IDLE SPEED CHECK - TK.
(15) COMPRESSION UNBALANCE TEST - DCA.
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE) (continued)
b. STE/ICE TROUBLESHOOTING
(2) STARTER CIRCUIT RESISTANCE - TEST 74
(3) BATTERY INTERNAL RESISTANCE (DCA) - TEST 73.
(4) BATTERY RESISTANCE CHANGE - TEST 75.
(5) STARTER NEGATIVE CABLE DROP - TEST 69
(6) GENERATOR FIELD VOLTAGE - TEST 83
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE) (continued). - TM-9-2350-287-20-1_467
(7) FUEL PRESSURE RETURN - TEST 49.
(8) CHARGING CIRCUIT (at battery) - TEST 67.
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE) (continued) - TM-9-2350-287-20-1_470
(9) ENGINE RPM - TEST 10.
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE) (continued) - TM-9-2350-287-20-1_472
(10) COMPRESSION UNBALANCE - TEST 14.
(11 ) ENGINE POWER PERCENTAGE - TEST 13.
(12) GENERATOR OUTPUT VOLTAGE - TEST 82.
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE) (continued).
(13) FUEL SUPPLY PRESSURE - (DCA AND TK) TEST 24.
SIMPLIFIED TEST EQUIPMENT FOR INTERNAL COMBUSTION ENGINES (STE/ICE) (continued). - TM-9-2350-287-20-1_478
(14) CRANKING CURRENT - TEST 71.
(15) CURRENT FIRST PEAK - TEST 72.
(16) STARTER SOLENOID VOLTAGE - TEST 70.
(17) VEHICLE OIL PRESSURE - TEST50.
(18) AIR FILTER PRESSURE DIFFERENTIAL - TEST 28.
(19) STARTER POSITIVE TERMINAL VOLTAGE - TEST 68
(20) INDIVIDUAL BATTERY VOLTAGE - TEST 89.
(21 ) AIR BOX PRESSURE - TEST 32.
(22) FUEL PRESSURE DROP - TEST 26.
2-24. CLEANING INSTRUCTIONS
2-25. INSPECTION INSTRUCTIONS.
2-28. LUBRICATION INSTRUCTIONS.
2-31. DEFINITION OF ADMINISTRATIVE STORAGE.
2-32. PREPARATION FOR ADMINISTRATIVE STORAGE (continued)
2-33. CARE OF EQUIPMENT IN ADMINISTRATIVE STORAGE.
2-36. PREPARATION OF EQUIPMENT FOR SHIPMENT.
2-36. PREPARATION OF EQUIPMENT FOR SHIPMENT (continued).
CHAPTER 3 POWERPACK MAINTENANCE
3-2. POWERPACK REPLACEMENT
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_499
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_500
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_501
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_502
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_503
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_504
b. INSTALLATION - TM-9-2350-287-20-1_505
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_506
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_507
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_508
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_509
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_510
POWERPACK REPLACEMENT (continued). - TM-9-2350-287-20-1_511
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_512
3-3 GROUND HOP PROCEDURES
GROUND HOP PROCEDURES (continued). - TM-9-2350-287-20-1_514
GROUND HOP PROCEDURES (continued). - TM-9-2350-287-20-1_515
GROUND HOP PROCEDURES (continued). - TM-9-2350-287-20-1_516
GROUND HOP PROCEDURES (continued). - TM-9-2350-287-20-1_517
GROUND HOP PROCEDURES (continued). - TM-9-2350-287-20-1_518
GROUND HOP PROCEDURES (continued). - TM-9-2350-287-20-1_519
GROUND HOP PROCEDURES (continued). - TM-9-2350-287-20-1_520
b. OPERATING PROCEDURES
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_522
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_523
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_524
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_525
c. REMOVAL PROCEDURES
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_527
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_528
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_529
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_530
GROUND HOP PROCEDURES (continued) - TM-9-2350-287-20-1_531
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_532
3-4. SHOCK MOUNT AND BRACKET REPLACEMENT.
b. INSTALLATION - TM-9-2350-287-20-1_534
3-5. OIL FILTER BRACKET REPLACEMENT
3-6. OIL COOLER HOSES REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_537
3-7. OIL SAMPLER SYSTEM REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_539
3-8. OIL FILTER AND OIL FILTER ADAPTER REPAIR.
d. INSTALLATION - TM-9-2350-287-20-1_541
3-9. LIQUID (LUBE OIL) LEVEL GAGE ROD AND TUBE ASSEMBLY REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_543
3-10. CRANKCASE AND GEAR TRAIN BREATHER TUBES REPLACEMENT
3-11.     CROSSOVER EXHAUST PIPE REPLACEMENT
3-12.     ACCESSSORY DRIVE ADDAPTER REPLACEMENT.
CHAPTER 4 FUEL SYSTEM MAINTENANCE
4-2. FUEL SYSTEM DRAINING
4-3 RIGHT ELECTRIC FUEL PUMP AND CHECK VALVE REPAIR.
b. DISASSEMBLY - TM-9-2350-287-20-1_550
RIGHT ELECTRIC FUEL PUMP AND CHECK VALVE REPAIR (continued) - TM-9-2350-287-20-1_551
c. INSPECTION - TM-9-2350-287-20-1_552
d. ASSEMBLY - TM-9-2350-287-20-1_553
RIGHT ELECTRIC FUEL PUMP AND CHECK VALVE REPAIR (continued) - TM-9-2350-287-20-1_554
INSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSTALLATIONINSINSTALLATION
4-4 LEFT ELECTRIC FUEL PUMP AND CHECK VALVE REPAIR.
b. DISASSEMBLY - TM-9-2350-287-20-1_557
LEFT ELECTRIC FUEL PUMP AND CHECK VALVE REPAIR (continued).
c. INSPECTION - TM-9-2350-287-20-1_559
d. ASSEMBLY - TM-9-2350-287-20-1_560
LEFT ELECTRIC FUEL PUMP AND CHECK VALVE REPAIR (continued)
e. INSTALLATION - TM-9-2350-287-20-1_562
4-5. APU CARGO COMPARTMENT FUEL HOSES, PUMPS, AND FITTINGS REPLACEMENT
APUCARGO COMPARTMENT FUEL HOSES, PUMPS, AND FITTlNGS REPLACEMENT (continued) - TM-9-2350-287-20-1_564
APUCARGO COMPARTMENT FUEL HOSES, PUMPS, AND FITTlNGS REPLACEMENT (continued) - TM-9-2350-287-20-1_565
APUCARGO COMPARTMENT FUEL HOSES, PUMPS, AND FITTlNGS REPLACEMENT (continued) - TM-9-2350-287-20-1_566
b. INSTALLATION - TM-9-2350-287-20-1_567
APU CARGO COMPARTMENT FUEL HOSES, PUMPS, AND FlTTlNGS REPLACEMENT (continued) - TM-9-2350-287-20-1_568
APU CARGO COMPARTMENT FUEL HOSES, PUMPS, AND FlTTlNGS REPLACEMENT (continued) - TM-9-2350-287-20-1_569
APU CARGO COMPARTMENT FUEL HOSES, PUMPS, AND FITTINGS REPLACEMENT (continued) - TM-9-2350-287-20-1_570
APU CARGO COMPARTMENT FUEL HOSES, PUMPS, AND FITTINGS REPLACEMENT (continued) - TM-9-2350-287-20-1_571
4-6. PERSONNEL HEATER FUEL PUMP REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_573
4-7. ENGINE-DRIVEN FUEL PUMP REPLACEMENT.
4-8. ENGINE-DRIVEN FUEL PUMP RELIEF VALVE REPLACEMENT
4-9. AIR CLEANER DUCTS AND HOSES REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_577
DUCTS AND HOSES REPLACEMENT (continued).
4-10. AIR CLEANER REPAIR
AIR CLEANER REPAIR (continued) - TM-9-2350-287-20-1_580
b. DISASSEMBLY - TM-9-2350-287-20-1_581
d. ASSEMBLY - TM-9-2350-287-20-1_582
AIR CLEANER REPAIR (continued) - TM-9-2350-287-20-1_583
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_584
4-11. AIR CLEANER BOX ASSEMBLY REPAIR
b. CLEANING AND INSPECTION - TM-9-2350-287-20-1_586
4-12. AIR CLEANER RESTRICTION INDICATOR REPLACEMENT
AIR CLEANER RESTRICTION INDICATOR REPLACEMENT (continued)
4-13. AIR CLEANER FAN ASSEMBLY REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_590
4-14. AIR CLEANER FILTER REPLACEMENT.
b. INSTALLATION - TM-9-2350-287-20-1_592
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_593
4-15. TURBOCHARGER OIL HOSES REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_595
4-16. POWERPACK FUEL LINES REPLACEMENT.
POWERPACK FUEL LINES REPLACEMENT (continued) - TM-9-2350-287-20-1_597
POWERPACK FUEL LINES REPLACEMENT (continued) - TM-9-2350-287-20-1_598
POWERPACK FUEL LINES REPLACEMENT (continued) - TM-9-2350-287-20-1_599
b. INSTALLATION - TM-9-2350-287-20-1_600
POWERPACK FUEL LINES REPLACEMENT (continued). - TM-9-2350-287-20-1_601
POWERPACK FUEL LINES REPLACEMENT (continued). - TM-9-2350-287-20-1_602
POWERPACK FUEL LINES REPLACEMENT (continued). - TM-9-2350-287-20-1_603
POWERPACK FUEL LINES REPLACEMENT (continued). - TM-9-2350-287-20-1_604
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_605
4-17. FUEL HOSES, LINES, AND FlTTINGS REPLACEMENT
FUEL HOSES, LINES, AND FlTTINGS REPLACEMENT (continued) - TM-9-2350-287-20-1_607
FUEL HOSES, LINES, AND FlTTINGS REPLACEMENT (continued) - TM-9-2350-287-20-1_608
FUEL HOSES, LINES, AND FlTTINGS REPLACEMENT (continued) - TM-9-2350-287-20-1_609
b. INSTALLATION - TM-9-2350-287-20-1_610
FUEL HOSES, LINES, AND FITTINGS REPLACEMENT (continued). - TM-9-2350-287-20-1_611
FUEL HOSES, LINES, AND FITTINGS REPLACEMENT (continued). - TM-9-2350-287-20-1_612
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_613
4-18. PRIMARY FUEL FILTER ASSEMBLY LIFTING BRACKET REPLACEMENT
4-19. SECONDARY FUEL FILTER ASSEMBLY LlFTING BRACKET REPLACEMENT.
4-20. FILLER NECK ASSEMBLY SEAL REPLACEMENT.
FILLER NECK ASSEMBLY SEAL REPLACEMENT (continued)
4-21. FILLER NECK ASSEMBLY REPLACEMENT
4-22. UPPER FUEL TANK LEVEL TRANSMlTTER REPLACEMENT.
b. INSTALLATION - TM-9-2350-287-20-1_620
4-23. LOWER FUEL TANK LEVEL TRANSMlTTER REPLACEMENT.
b. INSTALLATION - TM-9-2350-287-20-1_622
4-24. HEAT SHIELD REPAIR.
b. DISASSEMBLY - TM-9-2350-287-20-1_624
HEAT SHIELD REPAIR (continued) - TM-9-2350-287-20-1_625
c. CLEANING AND INSPECTION - TM-9-2350-287-20-1_626
HEAT SHIELD REPAIR (continued) - TM-9-2350-287-20-1_627
e. INSTALLATION - TM-9-2350-287-20-1_628
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_629
4-25. PRIMARY FUEL FILTER ASSEMBLY REPLACEMENT.
b. DISASSEMBLY - TM-9-2350-287-20-1_631
d. ASSEMBLY - TM-9-2350-287-20-1_632
4-26. SECONDARY FUEL FILTER ASSEMBLY REPLACEMENT.
SECONDARY FUEL FILTER ASSEMBLY REPLACEMENT (continued).
c. CLEANING AND INSPECTION
e. lNSTALLATION
4-27.      GLOW PLUG AND GLOW PLUG CONTROLLER REPLACEMENT
GLOW PLUG AND GLOW PLUG CONTROLLER REPLACEMENT (continued). - TM-9-2350-287-20-1_638
GLOW PLUG AND GLOW PLUG CONTROLLER REPLACEMENT (continued). - TM-9-2350-287-20-1_639
b. INSTALLATION - TM-9-2350-287-20-1_640
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_641
4-28. ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued)
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_644
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_645
b. DISASSEMBLY - TM-9-2350-287-20-1_646
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_647
c. CLEANING AND INSPECTION - TM-9-2350-287-20-1_648
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued).
e. INSTALLATION - TM-9-2350-287-20-1_650
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_651
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_652
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued)+
f. ADJUSTMENT - TM-9-2350-287-20-1_654
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_655
ACCELERATOR, THROTTLE, AND ENGINE CONTROL GOVERNOR REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_656
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_657
4-29. FUEL SHUTOFF ASSEMBLY REPLACEMENT
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_659
CHAPTER 5 EXHAUST   SYSTEM   MAINTENANCE
a. REMOVAL - TM-9-2350-287-20-1_662
b. INSTALLATION - TM-9-2350-287-20-1_663
5-3. EXHAUST DUCT AND PIPE INSULATION REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_665
CHAPTER 6 COOLING   SYSTEM   MAINTENANCE
6-2. PRESSURE RELIEF VALVE AND BLOCK MOUNT REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_669
6-3.   SURGE   TANK   REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_671
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_672
6-4. SURGE TANK HOSES REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_674
SURGE TANK HOSES REPLACEMENT (continued)
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_676
6-5. COOLING FAN UNIVERSAL JOINTS REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_678
6-6. RADIATOR AND MOUNTS REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_680
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_681
6-7. AERATION DETECTOR REPLACEMENT
b. DISASSEMBLY - TM-9-2350-287-20-1_683
AERATION DETECTOR REPLACEMENT (continued).
e. INSTALLATION - TM-9-2350-287-20-1_685
6-8. RADIATOR SHROUD REPLACEMENT.
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_687
6-9. MAIN ENGINE COOLANT CROSSOVER TUBE REPLACEMENT
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_689
6-10. ENGINE COOLANT TUBE REPLACEMENT.
b. INSTALLATION - TM-9-2350-287-20-1_691
6-11. INLET THERMOSTAT AND HOUSING ASSEMBLY REPLACEMENT.
INLET THERMOSTAT AND HOUSING ASSEMBLY REPLACEMENT (continued).
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_694
6-12. BYPASS THERMOSTAT AND HOUSING ASSEMBLY REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_696
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_697
CHAPTER 7 ELECTRICAL SYSTEM/CIRCUIT MAINTENANCE
Paragraph Title - TM-9-2350-287-20-1_700
7-2. GENERATOR (ALTERNATOR) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_702
7-3. VOLTAGE REGULATOR, BILGE PUMP RELAY, STARTER RELAY, CIRCUIT BREAKER, AND MOUNTING BRACKETS REPLACEMENT
VOLTAGE REGULATOR, BILGE PUMP RELAY, STARTER RELAY, CIRCUIT BREAKER, AND MOUNTING BRACKETS REPLACEMENT (continued). - TM-9-2350-287-20-1_704
VOLTAGE REGULATOR, BILGE PUMP RELAY, STARTER RELAY, CIRCUIT BREAKER, AND MOUNTING BRACKETS REPLACEMENT (continued). - TM-9-2350-287-20-1_705
VOLTAGE REGULATOR, BILGE PUMP RELAY, STARTER RELAY, CIRCUIT BREAKER, AND MOUNTING BRACKETS REPLACEMENT (continued). - TM-9-2350-287-20-1_706
b. INSTALLATION - TM-9-2350-287-20-1_707
VOLTAGE REGULATOR, BILGE PUMP RELAY, STARTER RELAY, CIRCUIT BREAKER, AND MOUNTING BRACKETS REPLACEMENT (continued)
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_709
7-4. RECTIFIER REPLACEMENT.
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_711
7-5. STARTER MOTOR REPLACEMENT.
STARTER MOTOR REPLACEMENT (continued).
b. INSTALLATION - TM-9-2350-287-20-1_714
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_715
7-6. DRIVERS PORTABLE INSTRUMENT PANEL REPAIR.
c. ASSEMBLY - TM-9-2350-287-20-1_717
DRIVERS PORTABLE INSTRUMENT PANEL REPAIR (continued)
d. INSTALLATION - TM-9-2350-287-20-1_719
7-8. LOW COOLANT INDICATOR LIGHT ASSEMBLY AND WIRING HARNESS (12260297) REPLACEMENT
7-9. DRIVER'S INSTRUMENT PANEL REPAIR.
DRIVERS INSTRUMENT PANEL REPAIR (continued)
b. DISASSEMBLY - TM-9-2350-287-20-1_724
d. INSTALLATION - TM-9-2350-287-20-1_725
7-10. ACCESSORY CONTROL BOX REPAIR.
b. DISASSEMBLY - TM-9-2350-287-20-1_727
ACCESSORY CONTROL BOX REPAIR (continued) - TM-9-2350-287-20-1_728
c. 1. ASSEMBLY
ACCESSORY CONTROL BOX REPAIR (continued) - TM-9-2350-287-20-1_730
ACCESSORY CONTROL BOX REPAIR (continued) - TM-9-2350-287-20-1_731
d. INSTALLATION - TM-9-2350-287-20-1_732
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_733
7-11. CIRCUIT BREAKER PANELS AND CIRCUIT BREAKER REPLACEMENT
d. INSTALLATION - TM-9-2350-287-20-1_735
7-12 AIR CLEANER BLOWER MOTOR RELAY REPLACEMENT
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_737
7-13. INTAKE FUEL PUMP SYSTEM RELAY REPLACEMENT
7-14. VENTILATION BLOWER RELAY REPLACEMENT
7-15. APU VOLTAGE REGULATOR REPLACEMENT
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_741
7-16. HYDRAULIC CONTROL GAGE PANEL ASSEMBLY REPAIR
HYDRAULIC CONTROL GAGE PANEL ASSEMBLY REPAIR (continued).
b. ASSEMBLY
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_745
7-17. CONVEYOR CONTROL SWITCH REPLACEMENT.
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_747
7-18. NBC POWER CONTROL BOX REPAIR
NBC POWER CONTROL BOX REPAIR (continued) - TM-9-2350-287-20-1_749
b. DISASSEMBLY - TM-9-2350-287-20-1_750
NBC POWER CONTROL BOX REPAIR (continued) - TM-9-2350-287-20-1_751
NBC POWER CONTROL BOX REPAIR (continued) - TM-9-2350-287-20-1_752
c. INSPECTION - TM-9-2350-287-20-1_753
NBC POWER CONTROL BOX REPAIR (continued) - TM-9-2350-287-20-1_754
NBC POWER CONTROL BOX REPAIR (continued) - TM-9-2350-287-20-1_755
e. 1. INSTALLATION
7-19. STE/lCE RESISTOR BOX REPLACEMENT
7-20. HEADLIGHT DIMMER, STOPLIGHT AND PARKING BRAKE LIGHT SWITCHES REPLACEMENT AND ADJUSTMENT
HEADLIGHT DIMMER, STOPLIGHT AND PARKING BRAKE LIGHT SWITCHES REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_759
b. 1. 2. c. 1. 2. d. 1. 2. PARKING BRAKE LIGHT SWITCH DISASSEMBLY
HEADLIGHT DIMMER, STOPLIGHT AND PARKING BRAKE LIGHT SWITCHES REPLACEMENT AND ADJUSTMENT (continued) - TM-9-2350-287-20-1_761
e. STOPLIGHT CONTROL SWITCH ADJUSTMENT
7-21. MASTER RELAY BOX REPLACEMENT.
7-22. APU CONTROL BOX REPAIR
APU CONTROL BOX REPAIR (continued). - TM-9-2350-287-20-1_765
APU CONTROL BOX REPAIR (continued). - TM-9-2350-287-20-1_766
APU CONTROL BOX REPAIR (continued). - TM-9-2350-287-20-1_767
c. ASSEMBLY - TM-9-2350-287-20-1_768
APU CONTROL BOX REPAIR (continued)
PREVENTIVE MAINTENANCE CHECKS AND SERVICES - cont - TM-9-2350-287-20-1_770
d. INSTALLATION - TM-9-2350-287-20-1_771
7-23. UPPER REAR DOOR CONTROL SWITCHES AND BRACKET REPLACEMENT
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_773
7-24. CONVEYOR OVERRIDE SAFETY SWITCH REPLACEMENT.
7-25. COMBAT OVERRIDE SWITCH ASSEMBLY REPLACEMENT.
7-26. INTERCOM POWER SUPPLY BRACKET REPLACEMENT
7-27. INTERCOM TERMINALS REPLACEMENT
7-28. REMOTE CHEMICAL DETECTOR ALARM TERMINALS REPLACEMENT
7-29. STOPLIGHT SWITCH REPLACEMENT AND ADJUSTMENT
c. ADJUSTMENT
7-30. DOME LIGHT REPAIR
b. DISASSEMBLY - TM-9-2350-287-20-1_782
c. ASSEMBLY - TM-9-2350-287-20-1_783
d. INSTALLATION - TM-9-2350-287-20-1_784
7-31. HEADLIGHT ASSEMBLY REPAIR
b. DISASSEMBLY - TM-9-2350-287-20-1_786
c. ASSEMBLY - TM-9-2350-287-20-1_787
d. INSTALLATION - TM-9-2350-287-20-1_788
f. ADJUSTMENT - TM-9-2350-287-20-1_789
7-32. HEADLIGHT SEALED-BEAM AND INCANDESCENT LAMP REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_791
7-33. LEFT TAlLLAMP ASSEMBLY REPAIR
b. DISASSEMBLY - TM-9-2350-287-20-1_793
c. ASSEMBLY - TM-9-2350-287-20-1_794
7-34. RIGHT TAlLLAMP ASSEMBLY REPAIR.
b. DISASSEMBLY - TM-9-2350-287-20-1_796
FOLLOW-ON   MAINTENANCE - TM-9-2350-287-20-1_797
7-35. STEERING SHAFT MASTER WARNING LIGHT REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_799
7-36. ENGINE COOLANT TEMPERATURE TRANSMlTTER REPLACEMENT
ENGINE COOLANT TEMPERATURE TRANSMlTTER REPLACEMENT (continued)
7-37. ENGINE COOLANT HIGH TEMPERATURE SWITCH REPLACEMENT
ENGINE COOLANT HIGH TEMPERATURE SWITCH REPLACEMENT (continued)
7-38. ENGINE OIL PRESSURE TRANSMITTER, ENGINE OIL LOW PRESSURE SWITCH, AND AIR CLEANER BLOWER MOTOR SWITCH REPLACEMENT
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_805
7-39. TRANSMISSION OIL TEMPERATURE TRANSMITTER AND OIL HIGH TEMPERATURE SWITCH REPLACEMENT
TRANSMISSION OIL TEMPERARE TRANSMlTTER AND OIL HIGH TEMPERATURE SWITCH REPLACEMENT (continued)
b. lNSTALLATION - TM-9-2350-287-20-1_808
7-40. TRANSMISSlON OIL PRESSURE TRANSMITTER AND OIL LOW PRESSURE SWITCH REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_810
7-41. BATTERY REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_812
7-42. BATTERY GROUND AND INTERCONNECTING CABLES (10897992, 10897993, 12330348) REPLACEMENT
BATTERY GROUND AND INTERCONNECTING CABLES (10897992, 10897993, 12330348) REPLACEMENT (continued)
b. INSTALLATION - TM-9-2350-287-20-1_815
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_816
7-43. BULKHEAD TO HEADLIGHT/BILGE PUMP WIRING HARNESS (10921380) REPAIR
BULKHEAD TO HEADLIGHT/BILGE PUMP WIRING HARNESS (1 0921380) REPAIR (continued) - TM-9-2350-287-20-1_818
BULKHEAD TO HEADLIGHT/BILGE PUMP WIRING HARNESS (1 0921380) REPAIR (continued) - TM-9-2350-287-20-1_819
BULKHEAD TO HEADLIGHTS/BILGE PUMP WIRING HARNESS (1 0921380) REPAIR (continued) - TM-9-2350-287-20-1_820
BULKHEAD TO HEADLIGHTS/BILGE PUMP WIRING HARNESS (1 0921380) REPAIR (continued) - TM-9-2350-287-20-1_821
b. 1. INSTALLATION - TM-9-2350-287-20-1_822
BULKHEAD TO HEADLIGHTS/BILGE PUMP WIRING HARNESS (10921380) REPAIR (continued). - TM-9-2350-287-20-1_823
BULKHEAD TO HEADLIGHTS/BILGE PUMP WIRING HARNESS (10921380) REPAIR (continued). - TM-9-2350-287-20-1_824
BULKHEAD TO HEADLIGHTS/BILGE PUMP WIRING HARNESS (10921380) REPAIR (continued). - TM-9-2350-287-20-1_825
FOLLOW-ON   MAINTENANCE - TM-9-2350-287-20-1_826
7-44. ENGINE DISCONNECT BRACKET TO BULKHEAD WIRING HARNESS (12268418-1) REPLACEMENT
ENGINE DISCONNECT BRACKET TO BULKHEAD WIRING HARNESS (12268418-1) REPLACEMENT (continued) - TM-9-2350-287-20-1_828
ENGINE DISCONNECT BRACKET TO BULKHEAD WIRING HARNESS (12268418-1) REPLACEMENT (continued) - TM-9-2350-287-20-1_829
ENGINE   DISCONNECT   BRACKET   TO   BULKHEAD   WIRING   HARNESS   (12268418-1)   REPLACEMENT (continued) - TM-9-2350-287-20-1_830
b. INSTALLATION - TM-9-2350-287-20-1_831
ENGINE   DISCONNECT   BRACKET   TO   BULKHEAD   WIRING   HARNESS   (12268418-1)   REPLACEMENT (continued) - TM-9-2350-287-20-1_832
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_833
7-45. BULKHEAD TO COMBAT OVERRIDE SWITCH LEAD ASSEMBLY (12268419) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_835
7-46. FUEL PUMP RELAY TO CIRCUIT BREAKER LEAD ASSEMBLY (11682358-1) REPLACEMENT.
7-47. FUEL PUMP SWITCH TO CIRCUIT BREAKER LEAD ASSEMBLY (11682358-2) REPLACEMENT.
b. INSTALLATION - TM-9-2350-287-20-1_838
7-48. DIODE HARNESS ASSEMBLY (12268417) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_840
7-49. ENGINE BRACKET TO DRIVERS BULKHEAD WIRING HARNESS (12353403) REPLACEMENT
ENGINE BRACKET TO DRIVERS BULKHEAD WIRING HARNESS (12353403) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_843
ENGINE BRACKET TO DRIVERS BULKHEAD WIRING HARNESS (12353403) REPLACEMENT (continued)
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_845
7-50. POWERPACK WIRING HARNESS (1 2268308) REPLACEMENT
POWERPACK WIRING HARNESS (12268308) REPLACEMENT (continued) - TM-9-2350-287-20-1_847
POWERPACK WIRING HARNESS (12268308) REPLACEMENT (continued) - TM-9-2350-287-20-1_848
b. INSTALLATION - TM-9-2350-287-20-1_849
POWERPACK WIRING HARNESS (1 2268308) REPLACEMENT (continued). - TM-9-2350-287-20-1_850
POWERPACK WIRING HARNESS (1 2268308) REPLACEMENT (continued). - TM-9-2350-287-20-1_851
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_852
7-51. ENGINE DISCONNECT BRACKET TO BATTERIES LEAD ASSEMBLY (1 2353401) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_854
7-52. STARTER TO ENGINE ELECTRICAL DISCONNECT CABLE ASSEMBLY (12353072) REPLACEMENT
STARTER   TO   ENGINE   ELECTRICAL   DISCONNECT   CABLE   ASSEMBLY   (12353072)   REPLACEMENT (continued) - TM-9-2350-287-20-1_856
STARTER   TO   ENGINE   ELECTRICAL   DISCONNECT   CABLE   ASSEMBLY   (12353072)   REPLACEMENT (continued) - TM-9-2350-287-20-1_857
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_858
7-53. POWERPACK WIRING HARNESS MOUNTING BRACKET REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_860
7-54. RECTIFIER TO REGULATOR WIRING HARNESS (12376406) REPLACEMENT.
b. INSTALLATION - TM-9-2350-287-20-1_862
7-55. BATTERY TO DRIVERS BULKHEAD WIRING HARNESS (12330317) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_864
7-56. BULKHEAD TO DRIVERS PORTABLE INSTRUMENT PANEL WIRING HARNESS (12260287) REPLACEMENT.
BULKHEAD TO DRIVERS PORTABLE INSTRUMENT PANEL WIRING HARNESS (12260287)   REPLACEMENT   (continued). - TM-9-2350-287-20-1_866
BULKHEAD TO DRIVERS PORTABLE INSTRUMENT PANEL WIRING HARNESS (12260287)   REPLACEMENT   (continued). - TM-9-2350-287-20-1_867
BULKHEAD TO DRIVERS PORTABLE INSTRUMENT PANEL WIRING HARNESS (12260287)   REPLACEMENT   (continued). - TM-9-2350-287-20-1_868
b. INSTALLATION - TM-9-2350-287-20-1_869
BULKHEAD TO DRIVERS PORTABLE INSTRUMENT PANEL WIRING HARNESS (12260287) REPLACEMENT (continued).
BULKHEAD TO DRIVERS PORTABLE INSTRUMENT PANEL WIRING HARNESS (12260287) REPLACEMENT (continued)
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_872
7-57. CARGO COMPARTMENT CABLE ASSEMBLY (12376405) REPLACEMENT
CARGO COMPARTMENT CABLE ASSEMBLY (12376405) REPLACEMENT (continued) - TM-9-2350-287-20-1_874
CARGO COMPARTMENT CABLE ASSEMBLY (12376405) REPLACEMENT (continued) - TM-9-2350-287-20-1_875
CARGO COMPARTMENT CABLE ASSEMBLY (12376405) REPLACEMENT (continued) - TM-9-2350-287-20-1_876
b. INSTALLATION - TM-9-2350-287-20-1_877
CARGO COMPARTMENT CABLE ASSEMBLY (12376405) REPLACEMENT (continued). - TM-9-2350-287-20-1_878
CARGO COMPARTMENT CABLE ASSEMBLY (12376405) REPLACEMENT (continued). - TM-9-2350-287-20-1_879
FOLLOW-ON TASKS - TM-9-2350-287-20-1_880
7-58. DRIVERS BULKHEAD TO BATTERIES AND SHUNT LEAD ASSEMBLY (12353402) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_882
7-59. DRIVERS BULKHEAD TO SLAVE RECEPTACLE WIRING HARNESS (12376573) REPLACEMENT
DRIVERS BULKHEAD TO SLAVE RECEPTACLE WIRING HARNESS (12376573) REPLACEMENT (continued)
b. INSTALLATION - TM-9-2350-287-20-1_885
FOLLOW-ON    MAINTENANCE - TM-9-2350-287-20-1_886
7-60. DRIVERS BULKHEAD TO APU VOLTAGE REGULATOR CABLE (12330256) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_888
7-61. DRIVERS INSTRUMENT PANEL WIRING HARNESS (12268104) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_890
7-62. INTANK FUEL PUMPS AND SYSTEM RELAY LEAD ASSEMBLY (12353646), LEAD ASSEMBLY (12353647), AND Y-CONNECTOR REPLACEMENT
7-63. AIR CLEANER BLOWER MOTOR RELAY LEAD ASSEMBLY (12353259) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_893
7-64. ACCESSORY CONTROL BOX TO AIR CLEANER BLOWER MOTORS, PERSONNEL HEATER WIRING HARNESS (12351544) REPAIR
b. DISASSEMBLY - TM-9-2350-287-20-1_895
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_896
7-65. DRIVERS COMPARTMENT DOME LIGHT TO PASSIVE NIGHT VIEWER CABLE ASSEMBLY (12332740) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_898
7-66. REAR NATO INTERVEHICULAR SLAVE RECEPTACLE REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_900
7-67. FRONT NATO INTERVEHICULAR SLAVE CONNECTOR REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_902
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_903
7-68. FRONT NATO INTERVEHICULAR SLAVE CONNECTOR GROUND LEAD (12332678) REPLACEMENT
FRONT NATO INTERVEHICULAR SLAVE CONNECTOR GROUND LEAD (12332678) REPLACEMENT (continued)
7-69. NBC WIRING HARNESS (12330296) REPLACEMENT
NBC WIRING HARNESS (12330296) REPLACEMENT (continued)
b. INSTALLATION - TM-9-2350-287-20-1_908
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_909
7-70. CONVEYOR   CONTROL   SWITCH   TO   CONVEYOR   OVERRIDE   SAFETY   SWITCH CABLE ASSEMBLY (1 2376544) REPLACEMENT
CONVEYOR CONTROL SWITCH TO CONVEYOR OVERRIDE SAFETY SWITCH CABLE ASSEMBLY (12376544) REPLACEMENT (continued)
7-71. APU CONTROL BOX TO APU VOLTAGE REGULATOR CABLE ASSEMBLY (12330248) REPAIR
APU CONTROL BOX TO APU VOLTAGE REGULATOR CABLE ASSEMBLY (12330248) REPAIR (continued). - TM-9-2350-287-20-1_913
APU CONTROL BOX TO APU VOLTAGE REGULATOR CABLE ASSEMBLY (12330248) REPAIR (continued). - TM-9-2350-287-20-1_914
APU CONTROL BOX TO APU VOLTAGE REGULATOR CABLE ASSEMBLY (12330248) REPAIR (continued). - TM-9-2350-287-20-1_915
b. DISASSEMBLY - TM-9-2350-287-20-1_916
APU CONTROL BOX TO APU VOLTAGE REGULATOR CABLE ASSEMBLY (12330248) REPAIR (continued) - TM-9-2350-287-20-1_917
APU CONTROL BOX TO APU VOLTAGE REGULATOR CABLE ASSEMBLY (12330248) REPAIR (continued) - TM-9-2350-287-20-1_918
APU CONTROL BOX TO APU VOLTAGE REGULATOR CABLE ASSEMBLY (12330248) REPAIR (continued) - TM-9-2350-287-20-1_919
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_920
7-72. INTERVEHICULAR GROUNDING CABLE AND STOWAGE STRAPS REPLACEMENT
7-73. TRAILER RECEPTACLE AND CABLE ASSEMBLY (12330246) REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_923
7-74. DCA TO DRIVER'S BULKHEAD STE/ICE WIRING HARNESS (12329996) REPLACEMENT
DCA TO DRIVERS BULKHEAD STE/lCE WIRING HARNESS (12329996) REPLACEMENT (continued)
b. INSTALLATION - TM-9-2350-287-20-1_926
7-75. DRIVERS BULKHEAD TO ENGINE DISCONNECT STE/lCE WIRING HARNESS (12329994) REPLACEMENT
DRIVERS BULKHEAD TO ENGINE DISCONNECT STE/lCE WIRING HARNESS (12329994) REPLACEMENT (continued)
b. . INSTALLATION
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_930
7-76. ENGINE TRANSDUCERS TO ENGINE ELECTRICAL DISCONNECT STE/lCE WIRING HARNESS (12329990) REPAIR.
ENGINE TRANSDUCERS TO ENGINE ELECTRICAL DISCONNECT STE/lCE WIRING HARNESS (12329990) REPAIR (continued)
b. DISASSEMBLY - TM-9-2350-287-20-1_933
d. INSTALLATION - TM-9-2350-287-20-1_934
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_935
7-77. CREW AFES ELECTRICAL WIRING HARNESSES REPLACEMENT.
c. HARNESS 12352315 REMOVAL
CREW AFES ELECTRICAL WIRING HARNESSES REPLACEMENT (continued) - TM-9-2350-287-20-1_938
d. HARNESS 12352315 INSTALLATION
CREW AFES ELECTRICAL WIRING HARNESSES REPLACEMENT (continued) - TM-9-2350-287-20-1_940
CREW AFES ELECTRICAL WIRING HARNESSES REPLACEMENT (continued) - TM-9-2350-287-20-1_941
e. 1. 2. 3. 4. 5. f. 1. 2. 3. 4. HARNESS 12352316 REMOVAL
g. HARNESS 12352353 REMOVAL
h. HARNESS 12352353 INSTALLATION
7-78. ENGINE AFES ELECTRICAL WIRING HARNESS (12352354) REPLACEMENT
ENGINE AFES ELECTRICAL WIRING HARNESS (12352354) REPLACEMENT -cont
b. INSTALLATION - TM-9-2350-287-20-1_947
ENGINE AFES ELECTRICAL WIRING HARNESS (12352354) REPLACEMENT (continued) - TM-9-2350-287-20-1_948
ENGINE AFES ELECTRICAL WIRING HARNESS (12352354) REPLACEMENT (continued) - TM-9-2350-287-20-1_949
7-79. ACCESSORY CONTROL BOX TO AFES HARNESSES, AFES RELAYS, AND PERSONNEL VENTILATION BLOWER WIRING HARNESS (12351461) REPAIR
ACCESSORY CONTROL BOX TO AFES HARNESSES, AFES RELAYS, AND PERSONNEL VENTILATION BLOWER WIRING HARNESS (12351461) REPAIR (continued) - TM-9-2350-287-20-1_951
ACCESSORY CONTROL BOX TO AFES HARNESSES, AFES RELAYS, AND PERSONNEL VENTILATION BLOWER WIRING HARNESS (12351461) REPAIR (continued) - TM-9-2350-287-20-1_952
b. DISASSEMBLY - TM-9-2350-287-20-1_953
d. INSTALLATION - TM-9-2350-287-20-1_954
ACCESSORY CONTROL BOX TO AFES HARNESSES, AFES RELAYS, AND PERSONNEL VENTILATION BLOWER WIRING HARNESS (12351461) REPAIR (continued) - TM-9-2350-287-20-1_955
FOLLOW-ON   MAINTENANCE - TM-9-2350-287-20-1_956
7-79.1. GLOBAL POSITIONING SYSTEM (GPS) POWER CABLE (12967942) REPAIR
b. DISASSEMBLY - TM-9-2350-287-20-1_958
7-80. WIRING HARNESS GUARDS REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_960
7-80.1. MOUNTED WATER RATION HEATER (MWRH) POWER CABLE (12447321)
c. ASSEMBLY - TM-9-2350-287-20-1_962
7-81. PERSONNEL VENTILATION BLOWER REPLACEMENT
CHAPTER 8 TRANSMISSION MAINTENANCE
8-2. SHIFT CONTROL LINKAGE REPAIR
SHIFT CONTROL LINKAGE REPAIR (continued). - TM-9-2350-287-20-1_967
SHIFT CONTROL LINKAGE REPAIR (continued). - TM-9-2350-287-20-1_968
b. DISASSEMBLY - TM-9-2350-287-20-1_969
SHIFT CONTROL LINKAGE REPAIR (continued). - TM-9-2350-287-20-1_970
SHIFT CONTROL LINKAGE REPAIR (continued). - TM-9-2350-287-20-1_971
c. CLEANING AND INSPECTION - TM-9-2350-287-20-1_972
d. ASSEMBLY - TM-9-2350-287-20-1_973
SHIFT CONTROL LINKAGE REPAIR (continued) - TM-9-2350-287-20-1_974
SHIFT CONTROL LINKAGE REPAIR (continued) - TM-9-2350-287-20-1_975
e. INSTALLATION
SHIFT CONTROL LINKAGE REPAIR (continued) - TM-9-2350-287-20-1_977
f. ADJUSTMENT - TM-9-2350-287-20-1_978
SHIFT CONTROL LINKAGE REPAIR (continued) - TM-9-2350-287-20-1_979
SHIFT CONTROL LINKAGE REPAIR (continued) - TM-9-2350-287-20-1_980
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_981
8-3. NEUTRAL SAFETY SWITCH REPLACEMENT
c. CLEANING AND INSPECTION - TM-9-2350-287-20-1_983
8-4. TRANSMISSION TRUNNION CAPS REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_985
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_986
8-5.   TRANSMISSION,   TRANSFER,   AND   DRIVE   CONTROL   ASSEMBLIES,   OIL   FILTER AND OIL COOLER HOSES REPLACEMENT
b. INSTALLATION - TM-9-2350-287-20-1_988
8-6. TRANSMISSION OUTPUT FLANGE REPLACEMENT
8-7. TRANSMISSION INTERNAL BRAKE ADJUSTMENT
TRANSMISSION INTERNAL BRAKE ADJUSTMENT (continued)
8-8. TRANSMISSION FILLER NECK REPLACEMENT
CHAPTER 9 TRANSFER, FINAL DRIVE, PLANETARY, AND DROP GEARBOX MAINTENANCE
a. REMOVAL - TM-9-2350-287-20-1_994
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_995
9-3. UNIVERSAL JOINT REPAIR
c. CLEANING AND INSPECTION - TM-9-2350-287-20-1_997
d. ASSEMBLY - TM-9-2350-287-20-1_998
FOLLOW-ON MAINTENANCE - TM-9-2350-287-20-1_999
9-4. FINAL DRIVE ASSEMBLY REPLACEMENT
FINAL DRIVE ASSEMBLY REPLACEMENT -cont
b. INSTALLATION - TM-9-2350-287-20-1_1002
FINAL DRIVE ASSEMBLY REPLACEMENT (continued)
FOLLOW ON MAINTENANCE
9-5. FINAL DRIVE SKID-PLATES REPLACEMENT
INDEX Volumes 1 and 2
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1008
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1009
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1010
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1011
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1012
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1013
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1014
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1015
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1016
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1017
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1018
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1019
INDEX Volumes 1 and 2 -cont - TM-9-2350-287-20-1_1020

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business