18. OIL CAN POINTS. Semiannually, 6 months or
11. STEERING HYDRAULIC FLUID TANK. Check oil level
3,000 miles (4,627 Km) Lubricate all pivot points.
daily. To check, look at tank. View A. Fluid must appear be-
windshield wiper shafts, seat adjustment rails. accel-
tween max and min marker. To fill, remove cap. Fill with
erator pedal and linkage. door hinges, mirror arms,
fluid as necessary. Put on tank cap.
tow hook and winch stop with OAI
12. BRAKE MASTER CYLINDER RESERVOIR. Chock fluid
19. WINCH. Chock oil level semiannually, 6 months or
level daily. To check, look into reservoir. View B. Fluid must
3,000 miles (4,827 Km). Place winch into winch mount.
appear 3/8 in. (10 mm) below filler opening. To fill, remove
Remove fill-drain plugs. View H. Oil must appear level with
cap. Fill with BFS.
bottom of fill plug opening. Fill with fluid as prescribed by
Lubricate semiannually, 6 months
13. BRAKE CALIPER.
key through fill-drain plug openings until oil begins to
or 3,000 miles (4,827 Km). To lubricate, apply a light film
overflow. Clean and install plug. Drain oil annually, 12
of GAA to brake caliper sliding surfaces only. View I
months or 6,000 miles (9,654 Km). To drain, place winch
on firm surface. Remove drain-fill plugs. View H. Drain
winch. Turn winch to where oil can drain from drain-fill
14. DAMPING CYLINDER ACCUMULATOR. Chock fluid
level semiannually, 6 months or 3,000 miles (4,827 Km).
holes. Place winch into winch mount. Refill with fluid as
To check, loosen air valve and reduce air pressure, remove
outlined above.
air valve. View L. Fluid level must be 2 3/4 in. (70 mm) above
bottom. Install air valve and pressurize to 87 14.5 psi
20. WINCH CABLE. Clean cable annually, 12 months or
(600 100 kPA). Check for leaks.
6,000 miles (9,654 Km). Apply CW-IIA to cable.
15. GREASE POINTS.
21. STEERING SYSTEM HYDRAULIC OIL FILTER.
Lubricate biennially, 24 months, or 12,000
(a) Hold grease gun on fitting. Pump grease until grease
miles (19,308 km). Remove oil filter. Replace with
comes out through seals.
new oil filter. Fill steering hydraulic fluid tank (see
Note 9, View A).
(b) Hold grease gun on fitting. Pump grease until grease
comes out through all four bearing cups. Rotate drive
22. IN-LINE FUEL FILTER. Semiannually, 6 months or
shaft if necessary.
3,000 miles (4,827 Km). Unscrew in-line fuel filter,
replace with new in-line fuel filter.
(c) Hold grease gun on fitting. Pump grease until grease
comes out of spline coupling.
23. WINDSHIELD WASHER RESERVOIR. Check fluid in
reservoir, reservoir should be approximately 3/4 full. See key
(d) Hold grease gun on fitting. Pump grease until grease
for proper fluid.
comes out of spring tension clip or seal.
24. The starter and alternator are lubricated at time of
16. BATTERY POST. Semiannually, 6 months or 3,000
assembly by supporting maintenance personnel.
miles (4,827 Km). Apply a light film of PT to battery post.
25. Copy of this Lubrication Order will remain with the
17. ROOF HATCH AND SIDE WINDOW LOCKS.
equipment at all times; instructions contained herein are
Lubricate semiannually, 6 months or 3,000 miles (4.827
mandatory.
Km). To lubricate apply a light film of GAA to roof hatch
and side window locks.
26. If OEA lubricant is required to meet the temperature
ranges prescribed in the Key, OEA lubricant is to be used in
place of OE/HDO.
By Order of the Secretary of the Army:
DENNIS J. REIMER
General, United States Army
Chief of Staff
YVONNE M. HARRISON
Administrative Assistant to the
Secretary of the Army
01043
DISTRIBUTION:
To be distributed in accordance with DA Form 12-37-E, block 1683, requirements for
LO 9-2350-272-12.
U . S . G O V E R N M E N T P R I N T I N G O F F I C E : 1997 0 - 418-283 (40474)
LO 9-2380-272-12
CARD 10 OF 10
PIN: 055026-000